Kawasaki Diesel MULE 4010 TRANS 4x4 (KAF950G9). Manual - part 17

 

  Index      Engines     Kawasaki Diesel MULE 4010 TRANS 4x4 (KAF950G9) - service manual

 

Search            

 

 

 

 

 

 

 

 

 

Content   ..  15  16  17  18   ..

 

 

Kawasaki Diesel MULE 4010 TRANS 4x4 (KAF950G9). Manual - part 17

 

 

2-46 PERIODIC MAINTENANCE

Periodic Maintenance Procedures

General Lubrication

Before lubricating each part, clean off any rusty spots with
rust remover and wipe off any grease, oil, dirt, or grime.

Lubricate the points listed below with indicated lubricant.

NOTE

Whenever the vehicle has been operated under
wet or rainy conditions, or especially after using a
high-pressure spray water, perform the general lubri-
cation.

Pivots and Points: Lubricate with Grease.

2WD/4WD Shift Lever Pivot
Brake Pedal Pivot
Cargo Bed Mounting Pins
Differential Shift Lever Pivot
Propeller Shaft Bearing [A] (under Fuel Tank)
Seat Brackets
Throttle Pedal Pivot
Transmission Shift Lever Pivot

Grease the propeller shaft bearing using the grease nip-
ple [B].

Cables: Lubricate with Grease.

2WD/4WD Shift Cable
Differential Shift Cable
Parking Brake Cables
Throttle Cable

Cables: Lubricate with Rust Inhibitor.

2WD/4WD Shift Cable
Differential Shift Cable
Throttle Cable

PERIODIC MAINTENANCE 2-47

Periodic Maintenance Procedures

With the cable disconnect at both ends, the cable should
move freely [A] within the cable housing.
If cable movement is not free after lubricating, if the cable
is frayed [B], or if the cable housing is kinked [C], replace
the cable.

Bolts, Nuts and Fasteners Tightness Inspection

Check the tightness of the bolts and nuts listed here. Also,
check to see that each cotter pin is in place and in good
condition.

NOTE

Check the engine fastener tightness when the engine is
cold (at room temperature).

If there are loose fasteners, first loosen by 1/2 turn, then
retorque them to the specified torque following the speci-
fied tightening sequence. Refer to the appropriate chap-
ter for torque specifications. If torque specifications are
not in the appropriate chapter, see the basic torque table.

Bolt, Nut, and Fasteners to be checked
Engine

Engine Mounting Bolts
Exhaust Pipe and Muffler Joint Bolts
Exhaust Pipe Holder Nuts
Fuel Tank Bolt and Nut
Muffler Mounting Bolts
Throttle Pedal Pivot Cotter Pin

Transmission/Final Drive

2WD/4WD Shift Lever Pivot Snap Pin
2WD/4WD Shift Shaft Lever Mounting Nut
Axle Nuts and Cotter Pins
Differential Shift Cable Upper End Snap Pin
Differential Shift Lever Pivot Snap Pin
Differential Shift Shaft Lever Mounting Nut
Hi/Low Shift Cable Upper End Snap Pin
Hi/Low Shift Lever Pivot Snap Pin
Hi/Low Shift Shaft Lever Mounting Nut
Propeller Shaft Bearing Housing Nuts
Shift Shaft Lever Clamp Bolts
Transmission Shift Cable Upper End Snap Pin

2-48 PERIODIC MAINTENANCE

Periodic Maintenance Procedures

Wheels

Wheel Nuts

Brakes

Brake Pedal Pivot Shaft Cotter Pin
Master Cylinder Mounting Bolts
Master Cylinder Push Rod Joint Cotter Pin
Parking Brake Cable Lower End Joint Cotter Pins
Parking Brake Lever Assembly Mounting Bolts

Suspension

Front Suspension Arm Pivot Bolts
Leaf Spring Mounting Nuts
Rear Shock Absorber Mounting Nuts
Strut Clamp Nuts and Cotter Pins
Strut Mounting Locknuts

Steering

Front Suspension Arm Joint Nuts and Cotter Pins
Steering Shaft Mounting Bolts and Nuts
Steering Wheel Mounting Nut
Tie-Rod End Locknuts
Tie-Rod End Nuts and Cotter Pins
Universal Joint Clamp Bolts

Frame

Battery Holder Mounting Nuts
Cargo Bed Hook Mounting Bolts
Cargo Bed Mounting Pin Snap Pins
Front and Rear Bar Mounting Bolts and Nuts
Front and Rear Seat Back Mounting Nuts
Front and Rear Seat Belt Mounting Bolts
Front and Rear Seat Belt Backle Mounting Bolts
Front Final Gear Case Skid Plate Mounting Bolts
Front Guard Nuts
Rear End Subframe Mounting Nuts
Seat Bracket Nuts

FUEL SYSTEM 3-1

3

Fuel System

Table of Contents

Exploded View........................................................................................................................

3-2

Specifications .........................................................................................................................

3-8

Special Tool ............................................................................................................................

3-9

Throttle Pedal and Cable........................................................................................................

3-10

Throttle Pedal Play Inspection ..........................................................................................

3-10

Throttle Pedal Play Adjustment.........................................................................................

3-10

Full Throttle Pedal Position Adjustment ............................................................................

3-10

Throttle Cable Installation .................................................................................................

3-11

Throttle Cable Lubrication.................................................................................................

3-11

Throttle Cable Inspection ..................................................................................................

3-11

Fuel Injection Nozzle ..............................................................................................................

3-12

Fuel Injection Nozzle Removal .........................................................................................

3-12

Fuel Injection Nozzle Installation ......................................................................................

3-12

Fuel Injection Nozzle Inspection .......................................................................................

3-12

Fuel Injection Pump................................................................................................................

3-15

Idle Speed Inspection .......................................................................................................

3-15

Idle Speed Adjustment......................................................................................................

3-15

Maximum Engine Speed Inspection .................................................................................

3-15

Maximum Engine Speed Adjustment................................................................................

3-15

Fuel Injection Pipe Removal .............................................................................................

3-15

Fuel Injection Pipe Installation ..........................................................................................

3-16

Fuel Injection Pump Removal ...........................................................................................

3-17

Fuel Injection Pump Installation ........................................................................................

3-17

Fuel Injection Pump Timing Inspection .............................................................................

3-18

Fuel Injection Pump Timing Adjustment ...........................................................................

3-19

Fuel Injection Pump Inspection and Repair ......................................................................

3-21

Fuel Injection Pump Troubleshooting .....................................................................................

3-22

Air Cleaner..............................................................................................................................

3-29

Air Cleaner Element Cleaning...........................................................................................

3-29

Air Cleaner Housing Removal...........................................................................................

3-30

Air Cleaner Housing Installation........................................................................................

3-30

Air Cleaner Housing Dust and/or Water Inspection ..........................................................

3-30

Fuel Filter................................................................................................................................

3-31

Fuel Filter Removal...........................................................................................................

3-31

Fuel Filter Installation........................................................................................................

3-31

Fuel Filter Cartridge Replacement ....................................................................................

3-31

Water Draining ..................................................................................................................

3-31

Fuel Tank ................................................................................................................................

3-32

Fuel Tank Removal ...........................................................................................................

3-32

Fuel Tank Installation ........................................................................................................

3-33

Fuel Tank Cleaning/Inspection..........................................................................................

3-35

Fuel Level Gauge Removal (KAF950G9

∼ GC/HA)..........................................................

3-36

Fuel Level Gauge Installation (KAF950G9

∼ GC/HA).......................................................

3-37

Fuel Level Gauge Check (KAF950G9

∼ GC/HA)..............................................................

3-37

Fuel Level Gauge Removal (KAF950GD).........................................................................

3-37

Fuel Level Gauge Installation (KAF950GD)......................................................................

3-38

 

 

 

 

 

 

 

Content   ..  15  16  17  18   ..