6500 WATT SILENTDIESEL GENERATOR. Manual - part 7
20
10. Troubleshooting & Solutions
Fault Cause
Remedy
Fuel oil is not sufficient
Refill the fuel oil
Fuel cock is not at the
STATE position
Turn it to START position
Fuel injection pump and
nozzle do not delivery the
fuel or delivery in
sufficient fuel
Remove the nozzle and repair
it at test table
The govemor lever is not
at START position
Set the lever to START position
Low oil
The specified oil level should
be between the upper level and
lower level
The nozzle is dirty
Clean the nozzle
The speed and force to
pull the recoil starter are
not enough
Start the engine according to
the start procedures included in
this book
The diesel
engine can not
start
The battery has no
electricity
Charge it or replace it with a
new one
Main switch not turned on
Turn the main switch to ON
position
The carbon brush is worn
Replace the carbon brush
The contact of the socket
is not good
Adjust the socket
The rated speed can no
be attached
Adjust it according to the
requirements
The generating
set can not
generate
AVR is damaged
Replace the AVR