Nissan Qashqai (2007-2010). Manual - part 745

BRC-178

< ON-VEHICLE REPAIR >

[ESP/TCS/ABS]

YAW RATE/SIDE G SENSOR

YAW RATE/SIDE G SENSOR

Exploded View

INFOID:0000000000924941

Removal and Installation

INFOID:0000000000924942

REMOVAL

CAUTION:

• Do not drop or strike yaw rate/side G sensor, because it has little endurance to impact.
• Do not use power tool etc., because yaw rate/side G sensor is sensitive for the impact.

1.

Remove lower instrument cover RH. Refer to 

IP-11, "Exploded View"

.

2.

Disconnect yaw rate/side G sensor harness connector.

3.

Remove mounting nuts. Remove yaw rate/side G sensor.

INSTALLATION

Note the following, and install in the reverse order of removal.

CAUTION:

• Do not drop or strike yaw rate/side G sensor, because it has little endurance to impact.
• Do not use power tool etc., because yaw rate/side G sensor is sensitive for the impact.

1.

Yaw rate/side G sensor

: Vehicle front

Refer to GI section 

GI-4, "Components"

 for symbol makes in the figure.

JSFIA0037GB

STEERING ANGLE SENSOR

BRC-179

< ON-VEHICLE REPAIR >

[ESP/TCS/ABS]

C

D

E

G

H

I

J

K

L

M

A

B

BRC

N

O

P

STEERING ANGLE SENSOR

Exploded View

INFOID:0000000000924943

Removal and Installation

INFOID:0000000000924944

REMOVAL

1.

Remove spiral cable assembly. Refer to 

SR-6, "Exploded View"

.

2.

Remove steering angle sensor from spiral cable assembly.

INSTALLATION

Note the following, and install in the reverse order of removal.

CAUTION:

After work, make sure to adjust neutral position of steering angle sensor. Refer to 

BRC-78, "ADJUST-

MENT OF STEERING ANGLE SENSOR NEUTRAL POSITION : Description"

.

1.

Steering angle sensor

: Vehicle front

JSFIA0003ZZ

ST-1

STEERING

C

D

E

F

H

I

J

K

L

M

SECTION 

ST

A

B

ST

N

O

P

CONTENTS

STEERING SYSTEM

SYMPTOM DIAGNOSIS  ...............................

2

NOISE, VIBRATION AND HARSHNESS 
(NVH) TROUBLESHOOTING  .............................

2

NVH Troubleshooting Chart  ......................................

2

PRECAUTION ...............................................

4

PRECAUTIONS ...................................................

4

Precaution for Supplemental Restraint System 
(SRS) "AIR BAG" and "SEAT BELT PRE-TEN-
SIONER" ...................................................................

4

Precaution Necessary for Steering Wheel Rota-
tion After Battery Disconnect .....................................

4

Service Notice or Precautions for Steering System 

......

4

PREPARATION ............................................

6

PREPARATION ...................................................

6

Special Service Tools ................................................

6

Commercial Service Tools  ........................................

6

ON-VEHICLE MAINTENANCE .....................

7

STEERING WHEEL .............................................

7

Inspection ..................................................................

7

ON-VEHICLE REPAIR ..................................

9

STEERING WHEEL  ...........................................

9

Exploded View ..........................................................

9

Removal and Installation  ..........................................

9

STEERING COLUMN ........................................

10

Exploded View .........................................................

10

Removal and Installation  .........................................

10

Inspection ................................................................

11

STEERING GEAR AND LINKAGE  ...................

13

Exploded View .........................................................

13

Removal and Installation  .........................................

15

Disassembly and Assembly .....................................

15

Inspection ................................................................

16

SERVICE DATA AND SPECIFICATIONS 
(SDS) ............................................................

18

SERVICE DATA AND SPECIFICATIONS 
(SDS) .................................................................

18

General Specifications .............................................

18

Steering Wheel Axial End Play and Play .................

18

Steering Wheel Turning Force .................................

18

Steering Angle  .........................................................

18

Steering Column Operating Range  .........................

18

Rack Stroke  .............................................................

19

Socket Swing Force and Rotating Torque ...............

19

Socket Axial End Play  .............................................

19

Inner Socket Length  ................................................

20

ST-2

< SYMPTOM DIAGNOSIS >

NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING

SYMPTOM DIAGNOSIS

NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING

NVH Troubleshooting Chart

INFOID:0000000000953487

2WD MODELS

Use the chart below to find the cause of the symptom. If necessary, repair or replace these parts.

×

: Applicable

4WD MODELS

Use the chart below to help you find the cause of the symptom. If necessary, repair or replace these parts.

Reference

ST

-1

6, "Ins

p

e

c

tio

n"

ST

-1

6, "Ins

p

e

c

tio

n"

ST

-1

6, "Ins

p

e

c

tio

n"

ST

-7,

 "I

nsp

e

c

tio

n"

ST

-7,

 "I

nsp

e

c

tio

n"

—

ST

-1

3, "Exp

lo

de

d 

V

ie

w

"

ST

-1

1

, "I

ns

pe

cti

o

n

"

ST

-1

0, "Exp

lo

de

d 

V

ie

w

"

ST

-1

3, "Exp

lo

de

d 

V

ie

w

"

NV

H

 in

 F

A

X

, R

A

X

, FS

U

, 

RS

U 

se

ct

ion

NV

H in

 WT 

se

cti

o

n

NV

H in

 WT 

se

cti

o

n

NV

H in

 F

A

X

 se

ct

io

n

N

V

H i

n

 BR se

cti

o

n

Possible cause and SUSPECTED PARTS

Ou

ter/

inn

e

r 

so

ck

et

 ba

ll 

jo

int

 swi

n

g

ing

 to

rqu

e

Ou

ter/

inn

e

r 

so

ck

et

 ba

ll 

jo

int

 rot

a

ti

ng

 to

rqu

e

Ou

ter/

inn

e

r so

ck

et

 ba

ll jo

int

 en

d pla

y

S

tee

ri

ng

 w

h

e

e

l 

pl

ay

Im

p

rop

er s

te

e

ri

ng 

whe

e

l

Im

p

rop

er i

n

s

ta

lla

tio

n

 o

r l

oos

e

nes

s

 of

 til

t l

o

c

k

 l

e

v

e

r

Mo

un

ti

n

g

 lo

o

s

en

es

s

S

tee

ri

ng

 c

o

lu

mn

 d

e

fo

rma

ti

o

n 

or 

d

a

m

a

g

e

Im

p

rop

er i

n

s

ta

lla

tio

n

 o

r l

oos

e

nes

s

 of

 st

ee

ring

 c

o

lu

m

n

S

te

e

rin

g

 lin

ka

ge

 lo

os

en

es

s

A

X

LE and 

SUSP

ENSION

TI

RE

S

ROAD W

H

EEL

DRIV

E

 SHAFT

BR

AK

E

S

Symptom

Steering

Noise

×

×

×

×

×

×

×

×

×

×

×

Shake

×

×

×

×

×

×

×

×

Vibration

×

×

×

×

×

×

×

×

Shimmy

×

×

×

×

×

×

×

Judder

×

×

×

×

×

×

×