Dodge Viper SRT (2015 year). Instruction

Cavity

Relay

Cartridge
Fuse

Mini-Fuse

Description

—

20 Amp
Yellow

—

Run Acc relay

—

B+ Jumper

—

Spare

—

10 Amp Red

ORC Mod Run

—

15 Amp Blue

Cluster, Camera

—

20 Amp
Yellow

Active Damping Suspension

—

10 Amp Red

HVAC Module, In Car Temp, Blower Relay

—

Spare

G8VA

—

Run/Start

G8VA

—

Fuel Door

MAINTAINING YOUR VEHICLE

347

Cavity

Relay

Cartridge
Fuse

Mini-Fuse

Description

43AC
(Forward
Fuse)

—

2 Amp Grey

SCCM

43BE
(Rearward
Fuse)

—

10 Amp Red

Corax

44AC
(Forward
Fuse)

—

10 Amp Red

Rear View Mirror, Aux Port Jumper.

44BE
(Rearward
Fuse)

—

10 Amp Red

IBS

—

10 Amp Red

PCM-Powertrain Control Module, Fuel Pump Relay.

—

10 Amp Red

ESC Module, Stop Lamp Switch

—

10 Amp Red

ORC Module, Passenger Seat OCM

348

MAINTAINING YOUR VEHICLE

Cavity

Relay

Cartridge
Fuse

Mini-Fuse

Description

—

10 Amp Red

SCCM

—

25 Amp
Clear

Amplifier

HC Micro

—

Rad Fan

HC Micro

—

Rad Fan Relay SER/PAR

HC Micro

—

Starter Relay

HC Micro

—

Rear Window Defroster Relay

HC Relay

—

Rad Fan Relay High

HC Micro

—

Wiper ON/OFF

HC Micro

—

Wiper LO/HI

G8VA

—

Horn Relay

G8VA

—

A/C Clutch Relay

HC Micro

—

HVAC Blower

HC Micro

—

Fuel Pump

MAINTAINING YOUR VEHICLE

349

Cavity

Relay

Cartridge
Fuse

Mini-Fuse

Description

G8VA

—

Run Relay #1

G8VA

—

Run Relay #2

HC Micro

—

ASD #1

HC Micro

—

ASD #2

G8VA

—

Run Accy #1, Pop Up, Driver Door Window Switch

NOTE:

A 15 Amp fuse for the radio system is located

in-line at the battery positive terminal.

CAUTION!

• When installing the power distribution center

cover, it is important to ensure the cover is properly
positioned and fully latched. Failure to do so may
allow water to get into the power distribution
center and possibly result in an electrical system
failure.

(Continued)

350

MAINTAINING YOUR VEHICLE

CAUTION! (Continued)

• When replacing a blown fuse, it is important to use

only a fuse having the correct amperage rating. The
use of a fuse with a rating other than indicated may
result in a dangerous electrical system overload. If
a properly rated fuse continues to blow, it indicates
a problem in the circuit that must be corrected.

VEHICLE STORAGE

We recommend that you follow these guidelines for
storing your vehicle for extended periods.
• Fill the fuel tank. This will prevent water condensation

inside the tank. If you plan to store your vehicle more
than two months, add an anti-oxidant fuel stabilizer to
the fuel tank.

• Change the oil to remove any corrosive combustion

related acids in the crankcase.

• Check that the radiator coolant level of protection is to

at least -20°F (-29°C).

• Make sure that all tires are inflated to the optimum

pressure.

• Wash and wax the vehicle to protect the finish.
• Store the vehicle in a dry, well-ventilated location.
• Move the wiper blades away from the windshield.
• Block the wheels. Do not apply the parking brake.
• Cut blocks of plywood about the same size of the tires.

Cover each block with indoor/outdoor carpeting and
place them between the tires and concrete. This will
prevent tire flat spotting.

• For long-term storage, remove the tires and put the

vehicle up on blocks. Stack the tires on plywood and
cover with a tarp to prevent flat spotting.

MAINTAINING YOUR VEHICLE

351

• If the vehicle will be subjected to freezing tempera-

tures, either remove the battery and store it in a dry,
well ventilated area or connect a trickle charger (1.5
Amp) with automatic shutdown / overcharge protec-
tion to the battery. However, do not leave the trickle
charger hooked up to the battery without being
plugged in to a 110 Volt AC outlet, as this will result in
further drain on the vehicle’s battery. If the vehicle is
not going to be driven in the next three weeks, perform
the battery recharge procedure in the Service Instruction.
Then, either disconnect the battery at the negative
terminal or use the “Battery Save Feature” to conserve
battery power. Refer to “Maintenance Procedures/
Battery Save Feature” in “Maintaining Your Vehicle”
for further information.

• Cover the vehicle whenever possible to prevent acci-

dental damage to the finish.

NOTE:

Disconnecting the battery causes the engine con-

trol system to lose memory of some “learned” functions.
After reconnecting the battery, the engine may run rough
until the control module “relearns” these functions. Us-
ing the Battery Save Feature will prevent the engine
controller from loosing its memory.

CAUTION!

Use care when disconnecting the remote positive
cable. It is connected to the battery and can short out
to any metal on the vehicle. Always tape or wrap the
exposed cable end to prevent electrical shorts.

352

MAINTAINING YOUR VEHICLE

Check the battery every four to six weeks to ensure that
the voltage is above 12.10 Volts. The voltage will drop
more rapidly in hot temperatures. If battery voltage
drops below 12.10 Volts, follow the battery recharge
procedure in the Service Instruction.

NOTE:

To help prevent the battery from discharging

during shorter periods of inactivity, perform the follow-
ing:

1. Make sure that the liftgate, hood, doors, windows are

completely closed.

2. Make sure that Remote Keyless Entry (RKE) transmit-

ter is operating and that the battery is good.

3. Make sure that the HOOD, LIFTGATE, and DOOR

switches are in adjustment. Perform the quick system
check, which follows:

Use the remote transmitter to set the alarm. If the alarm
SET light comes on and flashes, the system is operating
properly. If not, there is a problem with a switch or the
system. See your authorized dealer for service.

If you plan to store the vehicle longer than 30 days, we
recommend using Hibernation Mode to conserve bat-
tery power. Refer to “Hibernation Mode” in Mainte-
nance Procedures for further information.

MAINTAINING YOUR VEHICLE

353

REPLACEMENT BULBS

Interior Bulbs

Bulb Number

Message Center Indicators

103

Cluster

LED (Serviced at Authorized Dealer)

Gauge Pack

103

Heater Control

Interior Lamp

LED (Serviced at Authorized Dealer)

Courtesy Foot Well Lights

LED (Serviced at Authorized Dealer)

Cargo Lamp (Coupe Liftgate)

168

354

MAINTAINING YOUR VEHICLE

Exterior Bulbs

Bulb Number

Low/High Beam Headlamp

HID (Serviced at Authorized Dealer)

Front Park/Turn Signal Lamp

LED (Serviced at Authorized Dealer)

Daytime Running Lamp (DRL)

LED (Serviced at Authorized Dealer)

Front Side Marker Lamp

2821M

Center High Mounted Stop Lamp (CHMSL)

LED (Serviced at Authorized Dealer)

Tail/Stop/Turn Signal Lamp

LED (Serviced at Authorized Dealer)

Rear Marker Lamp

2821M

Backup Lamp

LED (Serviced at Authorized Dealer)

License Lamp

LED (Serviced at Authorized Dealer)

MAINTAINING YOUR VEHICLE

355

BULB REPLACEMENT

NOTE:

Lens fogging can occur under certain atmo-

spheric conditions. This will usually clear as atmospheric
conditions change to allow the condensation to change
back into a vapor. Turning the lamps on will usually
accelerate the clearing process.

Front Headlamp, Front Park/Turn Signal Lamp

For bulb replacement, see your authorized dealer.

Front/Rear Side Marker Lamp

For bulb replacement, see your authorized dealer.

Taillamp, Tail/Stop Lamp

For bulb replacement, see your authorized dealer.

Rear Turn Signal Lamp

For bulb replacement, see your authorized dealer.

Backup Lamps

For bulb replacement, see your authorized dealer.

356

MAINTAINING YOUR VEHICLE

FLUID CAPACITIES

U.S.

Metric

Fuel (Approximate)

16 Gallons

60.6 Liters

Engine Oil With Filter
We recommend you use synthetic SAE 0W-40, API Certified.

11 Quarts

10.4 Liters

Transmission
We recommend you use MOPAR® ATF+4® Automatic
Transmission Fluid.

3.4 Quarts

3.2 Liters

Rear Axle
We recommend you use Castrol SAF-XJ/SAE 75W-140 Syn-
thetic Gear and Axle Lubricant.

1.5 Quarts

1.4 Liters

Cooling System *
We recommend you use MOPAR® Antifreeze/Engine Cool-
ant (OAT coolant conforming to MS.90032) 10 Year/150,000
Mile Formula or equivalent).

16 Quarts

15 Liters

* Includes heater and coolant recovery bottle filled to MAX level.

MAINTAINING YOUR VEHICLE

357

FLUIDS, LUBRICANTS AND GENUINE PARTS

Engine

Component

Fluid, Lubricant, or Genuine Part

Engine Coolant

We recommend you use MOPAR® Antifreeze/Coolant 10 Year/150,000
Mile Formula OAT coolant conforming to MS.90032.

Engine Oil

We recommend you use a full synthetic 0W-40 engine oil such as MOPAR®
or Pennzoil Ultra or equivalent engine oil.

Engine Oil Filter

We recommend you use MOPAR® Engine Oil Filters.

Spark Plugs

We recommend you use MOPAR® Spark Plugs, see your authorized dealer.

Fuel Selection

We recommend you use Unleaded 91 Octane Only or Higher.

358

MAINTAINING YOUR VEHICLE

CAUTION!

• Mixing of engine coolant (antifreeze) other than

specified Organic Additive Technology (OAT) en-
gine coolant (antifreeze), may result in engine
damage and may decrease corrosion protection.
Organic Additive Technology (OAT) engine cool-
ant is different and should not be mixed with
Hybrid Organic Additive Technology (HOAT) en-
gine coolant (antifreeze) or any “globally compat-
ible” coolant (antifreeze). If a non-OAT engine
coolant (antifreeze) is introduced into the cooling
system in an emergency, the cooling system will
need to be drained, flushed, and refilled with fresh
OAT coolant (conforming to MS.90032), by an au-
thorized dealer as soon as possible.

(Continued)

CAUTION! (Continued)

• Do not use water alone or alcohol-based engine

coolant (antifreeze) products. Do not use additional
rust inhibitors or antirust products, as they may not
be compatible with the radiator engine coolant and
may plug the radiator.

• This vehicle has not been designed for use with

propylene glycol-based engine coolant (antifreeze).
Use of propylene glycol-based engine coolant (an-
tifreeze) is not recommended.

MAINTAINING YOUR VEHICLE

359

Chassis

Component

Fluid, Lubricant, or Genuine Part

Transmission

We recommend you use MOPAR® ATF+4® Automatic Transmis-
sion Fluid.

Rear Axle

We recommend you use Castrol SAF-XJ/SAE 75W-140 Synthetic
Gear and Axle Lubricant.

Brake/Clutch Master Cylinder

We recommend you use MOPAR® Brake and Clutch Fluid DOT 4
Motor Vehicle.

Power Steering Reservoir

We recommend you use MOPAR® Power Steering Fluid + 4,
MOPAR® or ATF+4® Automatic Transmission Fluid.

360

MAINTAINING YOUR VEHICLE

MAINTENANCE SCHEDULES

The Scheduled Maintenance services listed in this
instruction must be done at the times or mileages specified
to protect your vehicle warranty and ensure the best
vehicle performance and reliability. More frequent main-
tenance may be needed for vehicles in severe operating
conditions, such as dusty areas and very short trip
driving. Inspection and service should also be done
anytime a malfunction is suspected.

NOTE: Under no circumstances should oil change in-
tervals exceed 6,000 miles (10 000 km) or six months,
whichever comes first.

CAUTION!

Failure to perform the required maintenance items
may result in damage to the vehicle.

At Each Stop For Fuel

• Check the engine oil level about five minutes after a

fully warmed engine is shut off. Checking the oil level
while the vehicle is on level ground will improve the
accuracy of the oil level reading. Add oil only when
the level is at or below the ADD or MIN mark.

• Check the windshield washer solvent and add if

required.

362

MAINTENANCE SCHEDULES

Once A Month

• Check tire pressure and look for unusual wear or

damage. Rotate tires at the first sign of irregular wear,
even if it occurs before your next scheduled service.

• Inspect the battery, and clean and tighten the terminals

as required.

• Check the fluid levels of the coolant reservoir, brake

master cylinder, power steering, and transmission, and
add as needed.

• Check all lights and all other electrical items for correct

operation.

At Each Oil Change

• Change the engine oil filter.
• Inspect the exhaust system.

NOTE:

Also, inspect the exhaust system if you notice a

change in the sound of the exhaust system, or if the
exhaust fumes can be detected inside the vehicle.

• Inspect the brake hoses.
• Inspect the suspension components.
• Lubricate door hinges and check springs.
• Check the engine coolant level, hoses, and clamps.
• Check power steering fluid level.

MAINTENANCE SCHEDULES

363

Dodge Viper SRT (2015 year). Instruction - part 22